Product ID:JET A FUEL-PRIST
MSDS Date:03/30/2000
FSC:NIIN:Submitter:D DG
Status Code:A
MSDS Number: CLCXJ

Emergency Phone: 713-877-1400

Info Phone: 713-877-6732

Cage: 46684

Telephone: 713-877-6732

Cage: 46684

ALIPHATIC PETROLEUM DISTILLATE

CAS: 8008-20-6

RTECS: OA5500000

ACGIH TLV: 300 PPM

ETHYLENE GLYCOL MONOMETHYL ETHER

CAS: 109-86-4

RTECS: KL5775000

OSHA PEL 80 MG/M3;25 PPM

ACGIH TLV: 16 MG/M3;5 PPM

LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:MAY CAUSE MODERATE TO
SEVERE IRRITATION. SKIN: MODERATELY IRRITATING. INHALATION: MAY
CAUSE NAMAL AND RESPIRATORY TRACT. INGESTION: MAY CAUSE
GASTROINTESTINAL IRRITATION. CHRONIC: PROLONGED AND REPEATED
CONTACT WITH THE SKIN MAY CAUSE DEFATTING AND DERMATITIS.
Explanation of Carcinogenicity:NO DATA PROVIDED BY MANUFACTURER.
Effects of Overexposure:EYE: REDNESS, TEARING, OR BLURRED VISION. SKIN:
DRYING OF SKIN. INHALATION: MAY PRODUCE SYMPTOMS OF INTOXICATION,
SUCH AS HEADACHE, DIZZINESS, NAUSEA, WEAKNESS, FATIGUE, LOSS OF
COORDINATION AND CONSC IOUSNESS, EVEN DEATH. INGESTION: NAUSEA,
VOMITING OR DIARRHEA. ASPIRATION INTO THE LUNGS MAY CAUSE
HEMORRHAGING, PULMONARY EDEMA, PROGRESSING TO CHEMICAL PNEUMONITIS,
WHICH MAY BE FATAL.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS. MIDDLE DISTILLATES HAVE CAUSED SKIN CANCER AND KIDNEY
DAMAGE IN LABORATORY ANIMALS. THE FUEL ADDITIVE CONTAINS ETHYLENE
GLYCOL MONOMETHYL ETHER, WHICH HAS SHOWN

First Aid:EYE: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES,
INCLUDING UNDER THE EYELIDS. CONTACT A PHYSICIAN IMMEDIATELY. SKIN:
REMOVE CONTAMINATED CLOTHING & SHOES. WASH AFFECTED AREAS WITH SOAP
& FL USH WITH LARGE AMOUNTS OF WATER FOR 15 TO 20 MINUTES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
HAS STOPP ED APPLY ARTIFICIAL RESPIRATION. GET IMMEDIATE MEDICAL
ATTENTION. INGESTION: DO NOT INDUCE VOMITING. IF SPONTANEOUS
VOMITING OCCURS, KEEP HEAD BELOW HIPS. GET IMMEDIATE MEDICAL
ATTENTION.

Flash Point:=48.9C, 120.F
Autoignition Temp:=232.2C, 450.F
Lower Limits:0.7
Upper Limits:5.0
Extinguishing Media:DRY CHEMICAL, FOAM, OR CARBON DIOXIDE
Fire Fighting Procedures:USE WATER SPRAY TO COOL EXPOSED CONTAINERS.
USE A SMOTHERING TECHNIQUE FOR EXTINGUISHING FIRE OF THIS MATERIAL.
DO NOT USE A FORCED WATER STREAM DIRECTLY ON PETROLEUM FIRES AS
THIS WILL TEND TO SCATTE R THE FIRE. FIREFIGHTERS SHOULD WEAR SELF
CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND AND CAN BE IGNITED BY HEAT, POLOT LIGHTS,
OTHER FLAMES AND IGNTION SOURCES AT LOCATIONS DISTANT FROM MATERIAL
HANDLING POINT. FLOWING FUEL C AN BE IGNITED BY SELF-GENERATED
STATIC ELECTRICITY.

Spill Release Procedures:REMOVE SOURCES OF HEAT OR IGNITION INCLUDING
INTERNAL COMBUSTION ENGINES AND POWER TOOLS. CLEAN UP SPILL BUT DO
NOT FLUSH TO SEWER OR SURFACE WATER. VENTILATE AREA AND AVOID
VAPORS OR MISTS.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER

Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
A DRY COOL PLACE, AWAY FROM INCOMPATIBLE MATERIALS AND SOURCES OF
HEAT AND IGNITION. GROUND AND BOND ALL TRANSFER AND STORAGE
EQUIPMENT TO PREVENT STATIC SPARKS A ND EQUIP WITH SELF-CLOSING
VALVES, PRESSURE BUNGS AND FLAME ARRESTORS.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN RESIDUE (LIQUID AND/OR
VAOR) AND CAN BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE,
SOLDER, DRILL, GRIND OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME,
SPARKS OR OTHER SOUR CES OF IGNITION; THEY MAY EXPLODE AND CAUSE
INJURY OR DEATH.

Respiratory Protection:USE APPROVED RESPIRATORY PROTECTIVE EQUIPMENT
FOR CLEANING LARGE SPILLS OR ENTRY INTO LARGE TANKS, VESSELS, OR
OTHER CONFINED SPACES OR IN APPLICATIONS WHERE AIRBORNE
CONCENTRATIONS MAY EXCEED OCCUPAT IONAL EXPOSURE LEVELS.
Ventilation:PROVIDE ADEQUATE GENERAL AND LOCAL VENTILATION: 1) TO
MAINTAIN AIRBORNE CHEMICAL CONCENTRATIONS BELOW APPLICABLE EXPOSURE
LIMITS, 2) TO PREVENT ACCUMULATION OF
Protective Gloves:IMPERVIOUS GLOVES
Eye Protection:REMOVE CONTACT LENSES AND WEAR CHEMICAL SAFETY GLASSES
OR GOGGLES
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:NONE PROVIDED BY MFR
Supplemental Safety and Health
SYNONYMS: JET FUEL, DUAL PURPOSE KEROSENE, JET A, AV JET, KEROSENE.
NOTE: PRODUCT HAS NOT BEEN TESTED BY COASTAL CORPORATION TO
DETERMINE ITS SPECIFIC HEALTH HAZARDS. THEREFORE, THE INFORMATION
PROVID ED IN THIS SECTION INCLUDES HEALTH HAZARD INFORMATION ON THE
PRODUCT COMPONENTS.

HCC:F4
Boiling Pt:B.P. Text:320-554F @ 760 MMHG
Vapor Pres:MMHG @ 68F: 5
Vapor Density:5 (AIR=1)
Spec Gravity:0.8 (H2O=1)
Evaporation Rate & Reference:0.04 (ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WATER CLEAR TO COLORLESS LIQUID, MILD PETROLEUM
ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS OF USE.
AVOID HEAT, SPARKS, FLAME AND BUILD-UP OF STATIC ELECTRICITY,
HALOGENS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
HYDROCARBONS
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:NO DATA AVAILABLE

Toxicological Information:MAY AGGRAVATE PRE-EXISTING DERMATITIS. MIDDLE
DISTILLATES HAVE CAUSED SKIN CANCER AND KIDNEY DAMAGE IN LABORATORY
ANIMALS. THE FUEL ADDITIVE CONTAINS ETHYLENE GLYCOL MONOMETHYL
ETHER, WHICH HAS SHOWN EFEFCTS IN BLOOD FORMING TISSUES AFTER
CHRONIC EXPOSURES IN HUMANS AND ANIMALS. RECENT INHALATION STUDIES
IN THREE ANIMAL SPECIES HAVE PRODUCED EFFECTS IN THE BLOOD, THYMUS,
SPLEEN, LYMPHATIC TISSUE A ND TESTES OF RATS, WITH STERILITY
OCCURRING AT EXPOSURE OF 300 PPM. INHALATION STUDIES HAVE ALSO
SHOWN TERATOGENIC EFFECTS PRODUCED INRABBITS EXPOSED TO 50 PPM AND
RATS EXPOSED TO 100 PPM.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA AVAILABLE.

Transport Information:DOT SHIPPING NAME: FUEL, AVIATION, TURBINE
ENGINE. DOT HAZARD CLASS: 3 (COMBUSTIBLE LIQUID). DOT
IDENTIFICATION NUMBER: UN1863. DOT PACKING GROUP: III. THE
DESCRIPTION SHOWN MAY NOT APPLY TO ALL SHIPP ING SITUATIONS. SEE 49
CFR FOR ADDITIONAL REQUIREMENTS AND MODE/QUANTITY-SPECIFIC
TRANSPORT REQUIREMENTS.

SARA Title III Information:SECTION 302 EPCRA EXTREMELY HAZARDOUS
SUBSTANCES (EHS): NONE. SECTION 304 CERCLA HAZARDOUS SUBSTANCES:
NONE. SECTION 311/312 HAZARD CHARACTERISTICS: ACUTE: X, CHRONIC: X,
FIRE: X. SECTON 313 EPCRA TOX IC SUBSTANCES: ETHYLENE GLYCOL
MONOMETHYL ETHER, CAS# 109-86-4, 1%.
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER.
State Regulatory Information:CHEMICALS KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM MAY BE
FOUND IN CRUDE OIL AND PETROLEUM PRODUCTS. ALTHOUGH IT IS POSSIBLE
TO SUFFICIENTLY REFINE A CRUDE OIL OR ITS END PRODUCTS TO REMOVE
THE POTENTIAL FOR CANCER, WE ARE ADVISING THAT ONE OR MORE OF THE
LISTED CHEMICALS MAY BE PRESENT IN SOME DETECTABLE QUANTITIES. READ
AND FOLLOW DIRECTIONS AND USE CARE WHEN HANDLING CRUDE OIL AND
PETROLEUM PRODUCTS.